IEC60335-2-40-2013家用和类似用途电器--安全--第2-40部分:电气热泵、空调和减湿器的特殊要求

IEC60335-2-40-2013
中文名称： 家用和类似用途电器--安全--第2-40部分:电气热泵、空调和减湿器的特殊要求
英文名称： Household and similar electrical appliances – Safety – Part 2-40: Particular requirements for electrical heat pumps, air-conditioners and dehumidifiers
版本： 5.0  标准状态： 现行
中国标准分类
(CNS)： 【Y61】  国际标准分类
(ICS)： 【23.120】
发布日期： 2013-12-01  正版打印价格： 元
实施日期： 2013-12-01  页数： 76
废止日期：
适用范围： This clause of Part 1 is replaced by the following.
This part of IEC 60335 deals with the safety of electric heat pumps, including sanitary hot
water heat pumps, air-conditioners, and dehumidifiers incorporating motor-compressors
and hydronic room fan coils, their maximum rated voltages being not more than 250 V for
single phase appliances and 600 V for all other appliances.
Appliances not intended for normal household use but which nevertheless may be a source of
danger to the public, such as appliances intended to be used by laymen in shops, in light
industry and on farms, are within the scope of this standard.
This standard also applies to electric heat pumps, air conditioners and dehumidifiers
containing flammable refrigerant. Flammable refrigerants are defined in 3.121.
The appliances referenced above may consist of one or more factory made assemblies. If
provided in more than one assembly, the separate assemblies are to be used together, and
the requirements are based on the use of matched assemblies.
NOTE 101 A definition of ‘motor-compressor’ is given in IEC 60335-2-34, which includes the statement that the
term motor-compressor is used to designate either a hermetic motor-compressor or semi-hermetic motorcompressor.
NOTE 102 Requirements for refrigeration safety are covered by ISO 5149, and requirements for containers
intended for storage of the heated water included in sanitary hot water heat pumps are, in addition, covered by
IEC 60335-2-21.
This standard does not take into account chemicals other than group A1, A2, or A3 as defined
by ANSI/ASHRAE 34 [ISO 817] classification.
This standard specifies particular requirements for the use of flammable refrigerants. Unless
specifications are covered by this standard, including the annexes, requirements for
refrigerating safety are covered by ISO 5149.
The sections and clauses in ISO 5149 of particular concern to this standard are as follows:
– Section 3: "Design and construction of equipment" applies to all appliances and systems.
– Section 4: "Requirements for utilization" applies to appliances and systems which are for
“similar electrical appliances”, i.e. commercial and light industrial.
– Section 5: "Operating procedures" applies to appliances and systems which are for
“similar electrical appliances”, i.e. commercial and light industrial.
Supplementary heaters, or a provision for their separate installation, are within the scope of
this standard, but only heaters which are designed as a part of the appliance package, the
controls being incorporated in the appliance.
– – 60335-2-40 ? IEC:2013(E)
10
NOTE 103 Attention is drawn to the fact that
– for appliances intended to be used in vehicles or on board ships or aircraft, additional requirements may be
necessary;
– for appliances subjected to pressure, additional requirements may be necessary;
– in many countries, additional requirements are specified, for example, by the national health authorities
responsible for the protection of labour and the national authorities responsible for storage, transportation,
building constructions and installations.
NOTE 104 This standard does not apply to
– humidifiers intended for use with heating and cooling equipment (IEC 60335-2-88);
– appliances designed exclusively for industrial processing;
– appliances intended to be used in locations where special conditions prevail, such as the presence of a
corrosive or explosive atmosphere (dust, vapour or gas).
   引用了下列标准（标注*的引用文件，其最新版本适用于本标准）
  ANSI/ASHRAE 34-2010 
  ASTM D4728-01-2001  运输集装箱随机震动试验方法
  IEC 60068-2-52-1996  环境试验 第2-52部分:试验 试验Kb:循环盐雾(氯化钠溶液)
  IEC 60079-14-2013  电力变压器--第14部分：电气设施设计、选择和安装
  IEC 60079-15-2010  易爆环境.第15部分:"n"防护型电气设备保护
  IEC 60335-2-34-2012  家用和类似用途电器--安全--第2-34部分：电动机-压缩机的特殊要求
  IEC 60335-2-34-2012  家用和类似用途电器--安全--第2-34部分：电动机-压缩机的特殊要求
  IEC 60335-2-51-1997   家用和类似电器的安全.第2部分第51节:加热和供水装置的固定循环泵的特殊要求
  ISO 14903-2012  制冷系统和热泵--组件和连接件的密闭性鉴定
  ISO 5149-1993  制冷和加热用机械制冷系统.安全要求
  * ISO 7010-2011  图形符号--安全色和安全标志--已注册安全标志
  ISO 817-2005  有机制冷剂---命名系统
  代替了下列标准
  IEC 60335-2-40-2005  家用和类似用途电器--安全--第2-40部分:电气热泵,空调和减湿器的特殊要求
  被下列标准引用
  ISO 5149-2-2014  制冷系统制冷系统和热泵--安全和环境要求--第2部分：设计、建造、试验、标记与文件编制